Installation, Operation, and Maintenance Manual - For Gas Fryers - L20-072 Rev 7 - Safety Notices

Oct 28, 2026

Upload by 658056

Installation, operation, and maintenance manual content for gas fryers covering models 45C+, 35C+ and 40C+, plus 65. Includes safety-focused notices (NOTICE, CAUTION, WARNING), purchaser and operator instructions, grounding and electrical safety requirements, guidance against open flames for leak checks, and carbon monoxide and combustion/ventilation clearance warnings. Provides procedural cautions for installation, relighting, burner inspection, servicing isolation, and fuel type restrictions.

LanguageEnglish

CategoryHealthcare

FormatPDF

Pages47

Reading Time1 h 58 min

AccessFree to download

Table of Contents

List of Tables and Figures

Chapter 1: General Information and Installation

1.1 WHICH FRYER DO I HAVE?

1.2 CHECKING YOUR NEW FRYER

1.2.1 Check Your Order

1.3 ASSEMBLY AND LEVELING

1.3.1 Leg/Caster Installation and Adjustment

1.3.2 Assembling Multi Fryer Systems

1.4 INSTALLATION

1.4.1 Installation Clearances

| Installation, Operation, and Maintenance Manual
For Gas Fryers
CoveringModels 45C+, 35C+ and 40C+, 65
| | | | --- | --- | --- | | | | | ENGLISH FRANCAIS Pitco Frialator, Inc., P.O. Box 501, JctI-89 & I-93 Concord, NH 03302-0501 • 509 Route 3A, Bow, NH 03304 (603) 225-6684 • FAX (603) 225-8497 L20-072 Rev 7 (01/13) NOTICES There are three different types of notices that you should be familiar with, a NOTICE, CAUTION, and WARNING. A NOTICE is a special note used to call attention to a particularly important point. CAUTION is used to point out a procedure or operation which may cause equipment damage. The WARNING notice is the most important of the three because it warns ofan operation that may cause personal injury. Please familiarize yourself with your new cooker before operating it and heed the notices throughout this manual. The WARNINGS are listed below and on the following page foryour review prior to operating the unit. FOR YOUR SAFETY DO NOT store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance. WARNING: Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. Read the installation, operating and maintenance instructions thoroughly before installing or servicing this equipment. TO THE PURCHASER POST IN A PROMINENT LOCATION INSTRUCTIONS TOBE FOLLOWED IN THE EVENT THAT AN OPERATOR SMELLS GAS. OBTAIN THIS INFORMATION FROM YOUR LOCAL GAS SUPPLIER. THIS MANUAL MUST BE RETAINED FOR FUTURE REFERENCE ENGLISH | | | | | --- | --- | --- | | |
WARNING | | | | | | Thecookermust beelectricallygrounded inaccordancewith local codes. If local codes do not apply, follow the requirements of NationalCodeANSI/NFPA70-1990 . | | | | | --- | --- | --- | | |
WARNING | | | | | | This cookeris equipped with a three prong safety plug. This safety plug protectsoperatorsfromelectricalshockintheeventofanequipmentmalfunction. DO NOT remove the grounding (third) prong from this plug. | | | | | --- | --- | --- | | |
WARNING | | | | | | DO NOT use an open flame to check for gas leaks! | | | | | --- | --- | --- | | |
WARNING | | | | | | A cooker that is equipped with casters anda flexible power cord must be connected tothegas supply with a Quick-Disconnect device. This quick disconnectmustcomplywithANSIZ24.41-1989. Arestrainingcablemust be installed to limit the movement of the cooker. | | | | | --- | --- | --- | | |
WARNING | | | | | | There isanopengasflame insidethecooker. Theunit mayget hotenough to set nearby materialson fire. Keep the area around the cooker free from combustiblematerials. | | | | | --- | --- | --- | | |
WARNING | | | | | | Ensurethatthecookercangetenoughairtokeeptheflameburningcorrectly. If the flame is starved for air it can give off dangerous carbon monoxide. CarbonMonoxideisaclearodorlessgasthatcancausesuffocationanddeath. | | | | | --- | --- | --- | | |
WARNING | | | | | | Be sure the burner tubes are COMPLETELY covered with water before lighting the pilot or main burners. If the tubes are exposed, the cooker may overheat,causingdamagetothekettle,creatingafirehazard,andvoidingthe warranty. SAFETY SAFETY SAFETY SAFETY SAFETY | | | | | --- | --- | --- | | |
WARNING | | | | | | Carbon monoxide can buildup if the flue is blocked. Blocking the flue will alsocausethecookertooverheat. Ensurethatminimumclearancesspecified inthe installation instructions are maintained. DO NOTobstructtheflowof combustion/ventilationorairopeningaroundtheNoodleCooker. Adequate clearance around the cookeris necessary for servicing and proper burner operation. Ensure that you meet the minimum clearances specified in the installation instructions. | | | | | --- | --- | --- | | |
WARNING | | | | | | The power supply must be disconnected before servicing or cleaning the appli

FAQs

What do NOTICE, CAUTION, and WARNING mean in this manual?

A NOTICE highlights particularly important points. A CAUTION warns about procedures that may cause equipment damage. A WARNING is the most important notice and warns about operations that may cause personal injury.

What electrical grounding requirement must be followed?

The cooker must be electrically grounded according to local codes. If local codes do not apply, follow National Code ANSI/NFPA 70-1990, and do not remove the grounding (third) prong.

What safety steps are required before relighting the pilot for gas cookers?

Wait five (5) minutes before attempting to relight the pilot so any remaining gas in the cooker can dissipate.

Oct 28, 2026

Upload by 658056